服务热线:400-6688-603

来源:  日期:1970-01-01

  施工前准备
  Preparation before construction
  1.1检查建筑图纸,识别施工现场,防止停工或因问题返工。
  1.1 check the architectural drawings, identify the construction site, and prevent shutdown or rework due to problems.
  1.2抹灰层的平整度、强度等指标是否满足施工要求。
  1.2 whether the flatness, strength and other indicators of the plastering layer meet the construction requirements.
  1.3确认来料涂料的种类、颜色和数量,避免油漆开始后出现问题。
  1.3 confirm the type, color and quantity of the incoming paint to avoid problems after the paint starts.
  二是基本层次的要求和处理
山东喷绘膜广告
  Second, basic level requirements and handling
  2.1附着在基层上的各种杂物,如灰尘、油脂、铁锈、疏松、砂、粉等,应采用高压水洗、机械研磨等方式进行彻底清洗。
  2.1 all kinds of sundries attached to the base, such as dust, grease, rust, loose, sand, powder, etc., shall be thoroughly cleaned by means of high-pressure water washing, mechanical grinding, etc.
  2.2基层损坏、孔洞、裂缝、空胀壳等情况需提前修复,用腻子抹平,打磨光滑。阴阳角线应垂直,基准面平整度应控制在允许范围内。
  2.2 the damage of base course, holes, cracks, empty expansion shell, etc. shall be repaired in advance, trowelled with putty and polished smooth. The internal and external corners shall be vertical, and the flatness of the reference plane shall be controlled within the allowable range.
  2.3涂装施工时,基层含水率应小于10%。同时,在施工前要保证每个地块的含水率与主体墙体的含水率一致。
  2.3 during coating construction, the moisture content of base course shall be less than 10%. At the same time, the water content of each plot shall be consistent with that of the main wall before construction.
  2.4外墙如有松动、起砂、粉化现象,应彻底拆除后再用乳化砂浆进行修补。
  2.4 in case of looseness, sanding and pulverization of the external wall, it shall be completely removed and then repaired with emulsion mortar.
  2.5墙面装饰用塑料凹面线。如果需要油漆,必须清理沟槽;相反,在对沟槽进行薄油层处理前,涂布完毕,将油层擦除,充分恢复沟槽的本色。
  2.5 plastic concave line for wall decoration. If the paint is needed, the groove must be cleaned; on the contrary, before the groove is treated with thin oil layer, the coating is completed, the oil layer is erased, and the groove's natural color is fully restored.
  2.6新抹灰墙在腻子批嵌涂施工前应养护2周。
  2.6 the new plastered wall shall be cured for 2 weeks before the putty is applied.
  三、外墙涂料施工工艺
  3、 Construction technology of exterior wall coating
  3.1基本基本验收→清洗→批柔性耐水腻子2 *→用白色水性anti-alkali底漆一遍→用华润F42弹性画漆一遍→与华润H62弹性外墙漆防污漆2 *→清洁,清洁→验收
  3.1 basic acceptance → cleaning → batch of flexible water-resistant putty 2 * → one coat of white Waterborne Anti alkali primer → one coat of China Resources F42 elastic paint → one coat of anti fouling paint with China Resources H62 elastic exterior wall paint 2 * → cleaning, cleaning → acceptance
  3.2施工顺序:从上到下,先细节,再主要表面。
  3.2 construction sequence: from top to bottom, detail first, then main surface.
  3.3工序搭接:每次涂刷时用分割线与墙面阴、阳交接处或雨水为界。
  3.3 process lapping: when painting each time, the dividing line shall be used as the boundary between the Yin and Yang joints of the wall or the rain center.
  3.4滚涂施工。
  3.4 roll coating construction.
  3.5涂层系统:
  3.5 coating system:
  3.5.1底漆采用白色水基抗碱底漆,加水15%稀释,充分混合后使用。涂布均匀,无遗漏。施工至下一次施工的间隔时间不得少于12小时(室外25℃)。
  3.5.1 the primer shall be white water-based alkali resistant primer, diluted with 15% water, and fully mixed before use. The coating is even without omission. The interval between construction and the next construction shall not be less than 12 hours (outdoor 25 ℃).
  3.5.2中间涂漆采用弹性拉拔。要求镀层均匀、不流动、不脱落。施工后,与下一道工序的施工间隔不得小于4小时(室外,25℃)。
  3.5.2 elastic drawing is adopted for intermediate painting. It is required that the coating is uniform, does not flow and does not fall off. After construction, the construction interval with the next process shall not be less than 4 hours (outdoor, 25 ℃).
  3.5.3表面涂料采用2种防污弹性外墙涂料,一般用20%的水稀释。充分搅拌后,进行施工,然后一起使用。要求镀层均匀,无流动、无泄漏。
  3.5.3 two kinds of antifouling elastic exterior wall coatings are used for surface coating, which are generally diluted with 20% water. After full mixing, carry out construction, and then use together. The coating is required to be uniform without flow or leakage.
  以上是山东喷绘膜广告公司小编为大家介绍的相关内容,想要了解更多内容,欢迎访问网站:
  The above is the relevant content introduced by Shandong spray film advertising company. To learn more, please visit the website:
上一篇:具有自然广告元素的户外山东墙体广告
下一篇:为什么大公司喜欢到农村去“刷墙”做墙体广告?
XML 地图 | Sitemap 地图